HOW TO HANDLE THE HURRICANE

Hustling to beat the hurricanes: Workers hustle to get flue-cured leaf in barns in Wake County, N.C. (File photo by Chris Bickers)

With Florence bearing down, many of the flue-cured growers along the Atlantic Coast faced intense weather conditions with significant tobacco still in the field. Georgia might dodge the bullet since the path of the storm is expected to pass by it, and most of its crop has been harvested already (95 percent as of September 9, according to USDA). But South Carolina still had 10 percent unharvested, Virginia 35 percent, and in North Carolina, Extension specialist Matthew Vann reckons that 40 to 45 percent of the fields still have enough tobacco in them to be negatively affected by Florence. And the effect can be severe, Vann says. "You can expect heavy rains and very strong winds, and that will cause leaf whipping," he says. "It appears that we can expect at least a three-or-four-day wind. With the intensity of the conditions expected, the leaf is going to ripen extremely fast." To make matters worse, it has been coming off fast the last few weeks, and Vann feels most growers are already maxed out on barn space...What to do? Well, in the short term, the goal should be to minimize the leaf you lose as a result of electrical failure during the cure. Grant Ellington, Extension agricultural engineer at N.C. State, provided an excellent set of recommendations a few storms ago. I am going to print it below in hopes it will help you prepare for the worst.   Curing Tips Should adverse weather cause the loss of electrical current to the tobacco curing barn and a backup generator is not available, listed below are some tips that are recommended in order to minimize leaf damage. For tobacco that is being cured, the damage that might be sustained is related to the stage of cure when the power is lost and the condition of the tobacco when it is loaded into the barn. Tobacco that is in the very early or late stages of curing generally fairs the best when the power is out for extended periods. The following guidelines are useful when generator capacity is limited or not available: Yellowing (95 degrees WB/100 degrees DB) - about 24 hours - This period can be extended if the tobacco can be cooled to near outside temperatures before power outage occurs or as soon as possible after the outage occurs. Thereafter, the heat should be flushed every hour if the generator capacity is not sufficient to continue the cure normally. If a generator is not available, all air vents and doors should be opened to allow as much heat as possible to escape. Late yellowing/early leaf drying (105 degrees WB/105-115 degrees DB) - about 6 hours - This is the most critical period for damage and the tobacco should be cooled as soon as possible by any means available, with the heat being flushed every hour as suggested above. If sufficient generator capacity is not available and your area is expecting severe damage, tobacco that would be in this stage of curing during a prolonged power outage might be more profitable to the grower if it had not harvested. Leaf drying (105 degrees WB/120-135 DB) - about 24 hours - Extend the safe period by cooling as suggested above. Stem drying (110 degrees WB/150 degrees + DB) - several days - Attention to these barns can be delayed in order to provide attention to barns in the earliest stages of curing. Barn Loading Considerations Damage to tobacco during power outages is usually more severe in boxes than racks and particularly when containers are not loaded uniformly or loaded with wet tobacco. Therefore, tobacco harvested between now and the time the threat is passed should be harvested dry, loaded uniformly, and perhaps the containers should be loaded lighter than normal in order to maximize air movement and cooling potential should a power outage occur.   Don't forget about your greenhouses.  "Roll up curtains tight and secure doors," says Norman Harrell, Extension director in Wilson County, N.C. "If we lose power, you need to have backup power for the greenhouses to keep the plastic layers fully inflated."    BURLEY REPORT:  In East Tennessee, 2018 is beginning to look like a better-than-average season. "We have a good-looking crop," says Don Fowlkes, Agronomy Manager, Burley Stabilization Corporation. "There were the normal seasonal challenges, but now it appears that we have decent weight and the outlook for good quality also." At least half has been harvested and curing has gone well. Growers got a break in the first few weeks of curing. "It has beenunusually hot the past two or three weeks, but we have had good humidity so the tobacco hasn't cured too fast." Fowlkes has hopes that this crop may have plenty of the reddish color that buyers are looking for. In Kentucky, a fairly dark color seems on the way too, says Bob Pearce, Kentucky Extension toba-cco specialist. So far, there hasn't been significant flash curing. Like Tennessee, Kentucky has plenty of humidity. Maybe too much. Pearce fears there may be a problem of houseburn. Some Kentuckians got rain from Tropical Storm Gordon, but there hasn't been much rain since Sunday, Pearce says. "But it continues cloudy. We have had no sunshine for some time." More than half the Kentucky burley crop has been harvested, says Pearce.  "But not much more." The September USDA Crop Report was released at noon. Flue-cured tobacco production is expected to total 415 million pounds, the report says, down 10 percent from 2017. Burley tobacco production is expected to total 129 million pounds, down 20 percent from last year. Production projections by type and by state for flue-cured and burley follow. Flue-cured: North Carolina--322 million pounds, down 10.2 percent. Virginia--48.4 million pounds, down 4.3 percent. Georgia 22.5 million pounds, down 14.2 percent. South Carolina--21.600 million pounds, down 14.2 percent.                                                                Burley: Kentucky--106 million pounds million pounds, down 17.9 percent. Tennessee 10.200 million pounds, down 43.3 percent. North Carolina--1.360 million pounds, down 15.2 percent. Pennsylvania--10 million pounds, down 3.3 percent. Virginia--1.8 million pounds, down 18.1 percent. Fire-cured: 57.772 million pounds, down 2.9 percent.         Dark air-cured: 26.1 million pounds, up 29.5 percent. Pennsylvania seedleaf: 5.76 million pounds, up 33.3 percent.          Southern Maryland: 3.2 million pounds, down 25.4 percent. Note--The only types that (according to USDA) increased in production over 2017 are dark air-cured and Pennsylvania seedleaf, neither of which is used in cigarettes. To receive the newsletter in your email box, please click on "Join our mailing list" and follow the prompts. For more information, call 919-789 4631 or email cebickers@aol.com.